When a traveler unexpectedly tried to open a plane's exit door at cruising altitude during an international flight last week, it took a crowd of passengers and the brute force of smashing two wine bottles over his head to subdue him, according to news reports.
But perhaps unbeknownst to them, the passengers and plane crew also had physics on their side, an expert told Live Science.
Even if the man had been left to his own devices, he would have needed to exert more than 23,700 lbs. (10,700 kilograms) of force to open the door — equivalent to lifting 4.5 Humvees or nearly two African elephants. [5 Real Hazards of Air Travel]
The incident began when the man, identified as Joseph Hudek IV from Tampa, Florida, tried to open the exit door about an hour into a Delta Boeing 767 flight from Seattle to Beijing on July 6, according to an affidavit from the FBI. However, it appears that the man didn't have a full grasp of the physics of his situation.
The pressure inside a typical plane cabin never falls below that found 8,000 feet (2,400 meters) above sea level, said John-Paul Clarke, a professor of aerospace engineering and the director of the Air Transportation Laboratory at the Georgia Institute of Technology. Clarke was not involved with the Delta flight.
"The bottom line is that above 8,000 feet, the pressure inside is higher than the pressure outside," Clarke told Live Science in an email.
Furthermore, airplane doors are built so that the side nearest to the outside is smaller than the side nearest to the inside, Clarke said. This configuration means that a person cannot push open a closed door from the inside.
"You literally have to pull it inwards, turn it in some way and then push it outside" to open it, Clarke said.
Because of this door design, a person would have to fight a pressure difference to pull the door inward if the plane was cruising at more than 8,000 feet. "And at cruise altitude, that pressure difference is tremendous," Clarke said.
But just how much is this pressure difference? Clarke offered some rough estimates: The pressure at 8,000 feet is 10.92 lbs. per square inch (75,260 pascals), and the pressure at cruising altitude, or 36,000 feet (11,000 m), is 3.3 lbs. per square inch (23,000 Pa).
The door on a Boeing 767 measures about 74 inches by 42 inches (1.88 by 1.07 m), Clarke noted.
To calculate the force it would take to pull the door inward at 36,000 feet, you need to find the pressure difference and multiply it by the area of the door: 10.92 lbs. per square inch – 3.3 lbs. per square inch x 74 inches x 42 inches equals about 23,700 lbs.
That's a lot of force, as much as the weight of almost 30 grand pianos or nearly six adult male hippopotamuses. [15 of the Largest Animals of Their Kind on Earth]
However, the story changes if the plane is below 8,000 feet, Clarke said. "Below 8,000 feet, the pressure is controlled to match the pressure outside, hence the reason your ears only hurt the last 8,000 feet of the descent," he said.
Below that altitude, there is either a slight or no pressure difference between the inside and outside of the plane, "so it is much easier to pull the door open, as you would on the ground," Clarke said.
In last week's incident, the pilot turned the plane around and landed at the Seattle-Tacoma International Airport, where Port of Seattle Police Department officers apprehended Hudek, according to the FBI.
Original article on Live Science.
Sign up for the Live Science daily newsletter now
Get the world’s most fascinating discoveries delivered straight to your inbox.
Laura is the archaeology and Life's Little Mysteries editor at Live Science. She also reports on general science, including paleontology. Her work has appeared in The New York Times, Scholastic, Popular Science and Spectrum, a site on autism research. She has won multiple awards from the Society of Professional Journalists and the Washington Newspaper Publishers Association for her reporting at a weekly newspaper near Seattle. Laura holds a bachelor's degree in English literature and psychology from Washington University in St. Louis and a master's degree in science writing from NYU.